Gas leak in 300c fixed (Charger Magnum)





 My Chrysler 300c was leaking every time I filled the tank. I could smell the gas bad. I tracked down the leak to the seal on the fuel pump under the back seat.  The seat is snapped into place lift hard there are no screws.There was a little bit of gas on the rim shown here. I thought it was the hose but it was not. I bought the seal online for $25. I used the hammer and screwdriver method to spin the lock ring off. Notice were the grove is before taking it off.It took some hard swings.You can buy a tool if you like. This is the part other poster missed. You don’t have to pull the pump all the way out. Lift it up 3 inches and pull the old ring over top. The plugs on to will have to be removed but you don’t need to unplug all the hoses inside. Slide the new one over the top. When you get it lined up the pump should go back down into the same place it came out of. Don’t spin it. The lock ring will be tight you have a rounded gasket going in where the flat one was. I needed help here. Someone must push on the top of the pump so the lock ring will go on. While pushing down tap the ring to tighten. Don’t stop until the ring lines up no white should be showing on slots of ring. The ring has a grove where it should stop. Keep some rags handy a little gas may come out. Don’t drain it or turn it on to get the gas out of the lines this is a waist of time. You are not removing the pump if you do don’t unplug any hoses underneath and you should be fine.  I had little gas spillage a rag was good enough. You can put a baggy or something on the loose hose while you work.







Ring was pinched at the bottom. I have no idea how it lasted 120,000 before it leaked.


Don’t take any bottom hoses off slip it over the top



2005 Chrysler 300c a Charger and Magnum work the same way. Other years also work this way. 2009 2008 2007 2006


 Keyword stuff here. I smell gas every time I fill my Dodge Charger. I have a gas leak in my Magnum. My Chrysler 300c  is leaking gas.Fuel pump seal leaking. Fuel pump seal replaced. Fuel pump seal fixed.
 Some pictures were borrowed from the web.
Tip sponsored by Aaac service heating and air   
If this helped Like us on facebook thanks.


Aaac service residential furnace and air conditioner repair.7708754113




Share your views...

0 Respones to "Gas leak in 300c fixed (Charger Magnum)"

Posting Komentar

 

© 2010 SERVICE AC JOGJA All Rights Reserved Thesis WordPress Theme Converted into Blogger Template by Hack Tutors.info